2011 - 2013 Ford Transit / Tourneo Connect Fuse Box Diagram

2013 Ford Transit Connect

Fuses and Relays

 

If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing any electrical components.

Blown Fuse

 

 WARNING: Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage rating can cause severe wire damage and could start a fire.
If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing  any electrical components.

 

Standard Fuse Amperage Rating and Color 

 

COLOR
Fuse link cartridge	Cartridge maxi fuses	Maxi fuses	Standard fuses	Mini fuses	Fuse rating
- -	- -	- -	Grey	Grey	2A
- -	- -	- -	Violet	Violet	3A
- -	- -	- -	Pink	Pink	4A
- -	- -	- -	Tan	Tan	5A
- -	- -	- -	Brown	Brown	7.5A
- -	- -	- -	Red	Red	10A
- -	- -	- -	Blue	Blue	15A
Blue	Blue	Yellow	Yellow	Yellow	20A
Natural	Natural	- -	Natural	Natural	25A
Pink	Pink	Green	Green	Green	30A
Green	Green	Orange	- -	- -	40A
Red	Red	Red	- -	- -	50A
Yellow	Yellow	Blue	- -	- -	60A
Brown	- -	Tan	- -	- -	70A
Black	Black	Natural	- -	- -	80A

 

Frequently Asked Questions


When do I need to check a fuse?

If electrical components in the vehicle are not working.

When do I need to replace a fuse?

If a fuse has blown.

How do I identify a blown fuse?

You can identify a blown fuse by a broken wire within the fuse.

 

Power Distribution Box

WARNING: Always disconnect the battery before servicing high current fuses.
WARNING: To reduce risk of electrical shock, always replace the cover to the power   distribution box before reconnecting the battery or refilling fluid reservoirs.
The power distribution box is located in the engine compartment. It has high-current fuses that protect your vehicle’s main electrical systems from overloads.
If the battery has been disconnected and reconnected, see Changing the Vehicle Battery in the Maintenance chapter.
Note: To remove the power distribution box cover, the battery negative cable clip needs to be removed first. Pull up on the clip to detach it from the battery tray.

 

Power Distribution Fuse Box Diagram

 

The high-current fuses are coded as follows:

Fuse or relay location ... Fuse amp rating .. Protected circuits
1 7.5A* Heated windshield telltale
2 40A** Right heated windshield, Modified vehicle – Rear heater blower fan, Ignition supply
3 50A** Left heated windshield, Modified vehicle – Battery supply
4 20A** Fuel pump
5 10A* Powertrain control module keep alive power, Canister solenoid
6 15A* Powertrain control module, Data link connector
7 20A* Ignition switch
8 15A* Headlamps
9 40A** Passenger compartment fuse panel II
10 25A** Modified vehicle – Rear turn signal, Battery supply
11 40A** Ignition overload, Passenger compartment fuse panel
12 30A** Anti-lock brake system (ABS) / Roll stability control pump motor
13 30A* Heater blower motor

14 10A* Powertrain control module (PCM) relay
15 20A** Anti-lock brake system (ABS) / Roll stability control (RSC) valves
16 30A** Cooling fan – low
17 50A** Cooling fan – high
18 25A** Daytime running lamps (DRL), Low beam interrupt relay
19 50A** Passenger compartment fuse panel III
20 — A/C clutch relay
21A — Right heated windshield relay, Modified vehicle – Rear fan relay
21B — Starter lock relay
21C — High beam headlamp relay
21D — Powertrain control module relay
22 10A* Powertrain control module, Auxiliary connector, Fuel injectors
23 10A* Right low beam headlamp
24 10A* A/C clutch solenoid
25 10A* Left low beam headlamp
26 10A* Mass air flow sensor, Brake switch, Backup lamps relay, Exhaust gas recovery valve  stepper motor, Electronic vapor canister purge valve, Heated oxygen sensors, Floor shifter,  Transmission range sensor
27 — Not used

 

28 15A* Powertrain control module vehicle power 1
29 15A* Auxiliary connector, Coil on plugs
30A 70A Relay Cooling fan high relay
30B
30C — Cooling fan low relay
30D — Left heated windshield relay
31A — Backup lamp relay
31B — Fuel pump relay
31C — Daytime running lamps relay
31D — Low beam headlamps relay
31E — Modified vehicle – Right rear turn signal relay
31F — Front fog lamps
32 — Cooling fan diode
33 — Fuel pump relay diode
34 — Gear shifter diode
35 30A* Start lock relay
36 — Modified vehicle – Left rear turn signal relay

*Mini fuse **Cartridge fuse

 

Passenger Compartment Fuse Panel

The fuse panel and relay box are located below the instrument panel to the left of the steering wheel.

 

 Passenger Compartment Fuse Panel Diagram

The fuses are coded as follows:

Fuse or relay location ... Fuse amp rating  .... Protected circuits
117 — Not used
118 — Not used
119 — Not used
120 — Headlamps, Low beam interrupt relay
121 — Front fog lamp interrupt relay 

122 — Rear window defroster relay
123 — Heater blower relay
124 — Interior lamps relay
125 — Windshield wipers relay

 

126 — Rear unlock relay
127 — Ignition overload relay
128 — Battery saver relay (modified vehicle)
130 15A Hazard flashers
131 5A Power mirrors
132 10A Light switch, Exterior lighting
133 — Not used
134 — Not used
135 — Not used
136 15A Horn
137 7.5A Tire pressure monitoring system, Radio, Instrument cluster
138 10A Reverse lamp 

139 20A Ignition supply (modified vehicle)

140 — Not used
141 7.5A Front/rear fog lamps
142 15A Brake lamps
143 20A Cigar lighter (Cigarette Lighter) , Front power point
144 10A Ignition supply (modified vehicle)
145 — Not used
146 20A Windshield wipers, Wiper switch
147 15A Front fog lamps
148 7.5A Recirculation, Instrument cluster
149 10A Ignition supply/Battery supply (modified vehicle)
150 — Not used
151 15A Radio, Bluetooth®/Voice command module
152 7.5A A/C switch, Park aid module
153 7.5A Interior lamps, Battery saver
154 15A Roof lamp (modified vehicle)
155 10A Battery saver (modified vehicle)
156 7.5A Right parking lamp/tail lamps
157 7.5A License plate lamps
158 10A Light switch
159 20A Rear heater blower fan (modified vehicle)
160 — Not used
161 7.5A Anti-lock brake system (ABS) / Roll stability control, Steering angle sensor
162 7.5A Airbag module, Passenger airbag off indicator
163 20A Locks
164 20A Tire pressure monitoring system module
165 — Not used
166 25A Front power windows
167 7.5A Rear window defroster/heated mirror switch
168 — Not used
169 20A Second power point
170 — Not used
171 — Not used
172 10A Right rear turn signal (modified vehicle)
173 10A Left rear turn signal (modified vehicle)
174 20A Rear power point, Rear center console power point (modified vehicle)
175 7.5A Left park lamps/tail lamps
176 — Not used
177 — Not used
178 25A Rear window defroster
179 7.5A Instrument cluster, Passive anti-theft system, Accelerator pedal sensor, Tire pressure monitoring system, Rearview camera
180 20A Front and rear window washer
181 — Not used
182 — Not used